If you shop at Amazon.com (for anything), use this link to support FordTaurus.net!

Door Latch Lubrication

Post Reply
Magus732
Regular Member
Posts: 30
Joined: Sun Apr 01, 2018 1:34 pm
Vehicle: 2000 Taurus SE Comfort

Door Latch Lubrication

Post by Magus732 » Sun Jan 27, 2019 10:58 am

So, my 2000 Taurus with 142k miles decided she doesn't like to keep her front doors shut when it's below 20 or so degrees. I know after almost 20 years, the "lube" in the door latch's internal mechanism is probably total crap by now, if it's even still there. :? After she warms up, it's fine, but it means driving with the door partly hanging open until then.

My question is:
Other than removing the door panels, is there any way to get lubricating oil/fluid into the inside of the door latch, or do I simply have to remove them to do anything about this?

In case it hasn't become clear, I really, really, really don't want to have to remove the damn door panels, because althought right now it's only the front doors, with only hand tools to work with, it's going to take me forever to do both sides of the car.

I can take them off, again, to be clear; I simply don't want to waste time doing that if there's an easier way of doing it.
2000 Taurus SE Comfort - Graphite Blue - 3.0L Vulcan FFV
2011 Taurus SEL - Tuxedo Black - 3.5L Duratec 35


warment
Regular Member
Posts: 921
Joined: Wed Aug 31, 2005 6:13 am
Location: Virginia

Re: Door Latch Lubrication

Post by warment » Thu Jan 31, 2019 1:57 pm

I just went through this on my driver's door 2 days ago. I sprayed the latch/mechanism with silicone spray and didn't remove anything. It worked well this morning at less than 10 degrees.
2005 Ford Five Hundred SE
6-spd auto

warment
Regular Member
Posts: 921
Joined: Wed Aug 31, 2005 6:13 am
Location: Virginia

Re: Door Latch Lubrication

Post by warment » Thu Jan 31, 2019 1:58 pm

Then the pass door acted up this morning...wouldn't latch...so I sprayed it along with the other doors and trunk. I honestly think the problem is caused by the rubber coating on the mechanism. I have cut and pulled out what I could on other cars. Seems to help.
2005 Ford Five Hundred SE
6-spd auto

Magus732
Regular Member
Posts: 30
Joined: Sun Apr 01, 2018 1:34 pm
Vehicle: 2000 Taurus SE Comfort

Re: Door Latch Lubrication

Post by Magus732 » Thu Jan 31, 2019 2:37 pm

That's good to know; I'll try that after it comes back from getting the engine rebuilt. Her cylinder heads are warped from overheating; the water pump failed, the engine overheated in the -30 windchill yesterday, and the heads are egg-shaped now, so they have to be replaced. And so does the water pump. :x
2000 Taurus SE Comfort - Graphite Blue - 3.0L Vulcan FFV
2011 Taurus SEL - Tuxedo Black - 3.5L Duratec 35

warment
Regular Member
Posts: 921
Joined: Wed Aug 31, 2005 6:13 am
Location: Virginia

Re: Door Latch Lubrication

Post by warment » Thu Jan 31, 2019 6:43 pm

Wow. Good luck. I am about to go over 317k on my five hundred. I bought my mom a 2003 taurus Vulcan in 2003. Still has it and it runs great. Has a leaky timing cover though.
2005 Ford Five Hundred SE
6-spd auto

Magus732
Regular Member
Posts: 30
Joined: Sun Apr 01, 2018 1:34 pm
Vehicle: 2000 Taurus SE Comfort

Re: Door Latch Lubrication

Post by Magus732 » Fri Feb 01, 2019 10:50 am

warment wrote:
Thu Jan 31, 2019 6:43 pm
Wow. Good luck. I am about to go over 317k on my five hundred. I bought my mom a 2003 taurus Vulcan in 2003. Still has it and it runs great. Has a leaky timing cover though.
Got the money approved for the repair. 8)
You might want to have someone look at that timing cover; those leaks are only going to get worse. :?
2000 Taurus SE Comfort - Graphite Blue - 3.0L Vulcan FFV
2011 Taurus SEL - Tuxedo Black - 3.5L Duratec 35

Post Reply